a-comparative-analysis-recombinant-protein-expression-different

A Comparative Analysis of Recombinant Protein Expression in Different Biofactories: Bacteria, Insect Cells and Plant Systems

Plant-based systems are considered a valuable platform for the production of recombinant proteins as a result of their well-documented potential for the ...

transient-expression-red-beet-biopharmaceutical-candidate-vaccine-for

Transient Expression in Red Beet of a Biopharmaceutical Candidate Vaccine for Type-1 Diabetes

Plant molecular farming is the use of plants to produce molecules of interest. In this perspective, plants may be used both as bioreactors for the ...

University of Verona, Verona, Italy

University of Verona

The 65-kDa isoform of glutamic acid decarboxylase (GAD65) is the major autoantigen implicated in the development of type 1 diabetes mellitus (T1DM). The bulk manufacture of GAD65 is a potential issue in the fight against T1DM but current production platforms are expensive. We show that a catalytically inactive form of GAD65 (GAD65mut) accumulates at up to 2.2% total soluble protein in transgenic tobacco leaves, which is more than 10-fold the levels achieved with active GAD65, yet the protein retains the immunogenic properties required to treat T1DM. This higher yield was found to be a result of a higher rate of protein synthesis and not transcript availability or protein stability. We found that targeting GAD65 to the endoplasmic reticulum, a strategy that increases the accumulation of many recombinant proteins expressed in plants, did not improve production of GAD65mut. The production of a catalytically inactive autoantigen that retains its immunogenic properties could be a useful strategy to provide high-quality therapeutic protein for treatment of autoimmune T1DM.

Recombinant human GAD65 accumulates to high levels in transgenic tobacco plants when expressed as an enzymatically inactive mutant.

The 65-kDa isoform of human glutamic acid decarboxylase (hGAD65) is a major diabetes autoantigen that can be used for the diagnosis and (more recently) the treatment of autoimmune diabetes. We previously reported that a catalytically-inactive version (hGAD65mut) accumulated to tenfold higher levels than its active counterpart in transgenic tobacco plants, providing a safe and less expensive source of the protein compared to mammalian production platforms. Here we show that hGAD65mut is also produced at higher levels than hGAD65 by transient expression in Nicotiana benthamiana (using either the pK7WG2 or MagnICON vectors), in insect cells using baculovirus vectors, and in bacterial cells using an inducible-expression system, although the latter system is unsuitable because hGAD65mut accumulates within inclusion bodies. The most productive of these platforms was the MagnICON system, which achieved yields of 78.8 μg/g fresh leaf weight (FLW) but this was substantially less than the best-performing elite transgenic tobacco plants, which reached 114.3 μg/g FLW after six generations of self-crossing. The transgenic system was found to be the most productive and cost-effective although the breeding process took 3 years to complete. The MagnICON system was less productive overall, but generated large amounts of protein in a few days. Both plant-based systems were therefore advantageous over the baculovirus-based production platform in our hands.

Comparative analysis of different biofactories for the production of a major diabetes autoantigen.

In recent years, the production of recombinant pharmaceutical proteins in heterologous systems has increased significantly. Most applications involve complex proteins and glycoproteins that are difficult to produce, thus promoting the development and improvement of a wide range of production platforms. No individual system is optimal for the production of all recombinant proteins, so the diversity of platforms based on plants offers a significant advantage. Here, we discuss the production of four recombinant pharmaceutical proteins using different platforms, highlighting from these examples the unique advantages of plant-based systems over traditional fermenter-based expression platforms.

Comparative evaluation of recombinant protein production in different biofactories: the green perspective.

The 65-kDa isoform of human glutamic acid decarboxylase (hGAD65) is a major autoantigen in autoimmune diabetes. The heterologous production of hGAD65 for diagnostic and therapeutic applications is hampered by low upstream productivity and the absence of a robust and efficient downstream process for product isolation. A tobacco-based platform has been developed for the production of an enzymatically-inactive form of the protein (hGAD65mut), but standard downstream processing strategies for plant-derived recombinant proteins cannot be used in this case because the product is amphiphilic. We therefore evaluated different extraction buffers and an aqueous micellar two-phase system (AMTPS) to optimize the isolation and purification of hGAD65mut from plants. We identified the extraction conditions offering the greatest selectivity for hGAD65mut over native tobacco proteins using a complex experimental design approach. Under our optimized conditions, the most efficient initial extraction and partial purification strategy achieved an overall hGAD65mut yield of 92.5% with a purification factor of 12.3 and a concentration factor of 23.8. The process also removed a significant quantity of phenols, which are major contaminants present in tobacco tissue. This is the first report describing the use of AMTPS for the partial purification of an amphiphilic recombinant protein from plant tissues and our findings could also provide a working model for the initial recovery and partial purification of hydrophobic recombinant proteins from transgenic tobacco plants.

A downstream process allowing the efficient isolation of a recombinant amphiphilic protein from tobacco leaves.

Oxygenic photosynthetic organisms evolved mechanisms for thermal dissipation of energy absorbed in excess to prevent formation of reactive oxygen species. The major and fastest component, called non-photochemical quenching, occurs within the photosystem II antenna system by the action of two essential light-harvesting complex (LHC)-like proteins, photosystem II subunit S (PSBS) in plants and light-harvesting complex stress-related (LHCSR) in green algae and diatoms. In the evolutionary intermediate Physcomitrella patens, a moss, both gene products are active. These proteins, which are present in low amounts, are difficult to purify, preventing structural and functional analysis. Here, we report on the overexpression of the LHCSR1 protein from P. patens in the heterologous systems Nicotiana benthamiana and Nicotiana tabacum using transient and stable nuclear transformation. We show that the protein accumulated in both heterologous systems is in its mature form, localizes in the chloroplast thylakoid membranes, and is correctly folded with chlorophyll a and xanthophylls but without chlorophyll b, an essential chromophore for plants and algal LHC proteins. Finally, we show that recombinant LHCSR1 is active in quenching in vivo, implying that the recombinant protein obtained is a good material for future structural and functional studies.

Heterologous expression of moss light-harvesting complex stress-related 1 (LHCSR1), the chlorophyll a-xanthophyll pigment-protein complex catalyzing non-photochemical quenching, in Nicotiana sp.

Plants have emerged as competitive production platforms for pharmaceutical proteins that are required in large quantities. One example is the 65-kDa isoform of human glutamic acid decarboxylase (GAD65), a major autoimmune diabetes autoantigen that has been developed as a vaccine candidate for the primary prevention of diabetes. The expression of GAD65 in plants has been optimized but large-scale purification is hampered by its tendency to associate with membranes. We investigated the potential for large-scale downstream processing by evaluating different combinations of plant-based expression systems and engineered forms of GAD65 in terms of yield, subcellular localization and solubility in detergent-free buffer. We found that a modified version of GAD65 lacking the first 87 amino acids accumulates to high levels in the cytosol and can be extracted in detergent-free buffer. The highest yields of this variant protein were achieved using the MagnICON transient expression system. This combination of truncated GAD65 and the MagnICON system dramatically boosts the production of the recombinant protein and helps to optimize downstream processing for the establishment of a sustainable plant-based production platform for an autoimmune diabetes vaccine candidate.

Enhanced GAD65 production in plants using the MagnICON transient expression system: Optimization of upstream production and downstream processing.

Type-1 diabetes (T1D) is a metabolic disease involving the autoimmune destruction of insulin-producing pancreatic beta cells. It is often diagnosed by the detection of autoantibodies, typically those recognizing insulin itself or the 65-kDa isoform of glutamic acid decarboxylase (GAD65). Oral insulin can be used to induce systemic immunological tolerance and thus prevent or delay the onset of T1D, suggesting that combination treatments with other autoantigens such as GAD65 could be even more successful. GAD65 has induced oral tolerance and prevented T1D in preclinical studies but it is difficult to produce in sufficient quantities for clinical testing. Here we combined edible plant systems, namely spinach ( cv Industra) and red beet ( cv Moulin Rouge), with the magnICON expression system to develop a safe, cost-effective and environmentally sustainable platform for the large-scale production of GAD65. The superior red beet platform was extensively characterized in terms of recombinant protein yields and bioequivalence to wild-type plants, and the product was tested for its ability to resist simulated gastric digestion. Our results indicate that red beet plants are suitable for the production of a candidate oral vaccine based on GAD65 for the future preclinical and clinical testing of T1D immunotherapy approaches.

ArticleTotal : 2	Year
Publication title Cited by 43	2015
Publication title Cited by 3	2019

Article	Year
Recombinant human GAD65 accumulates to high levels in transgenic tobacco plants when expressed as an enzymatically inactive mutant. Plant biotechnology journal\| PubMed ID: 20374524	2010
Comparative analysis of different biofactories for the production of a major diabetes autoantigen. Transgenic research\| PubMed ID: 24142387	2014
Comparative evaluation of recombinant protein production in different biofactories: the green perspective. BioMed research international\| PubMed ID: 24745008	2014
A downstream process allowing the efficient isolation of a recombinant amphiphilic protein from tobacco leaves. Journal of chromatography. B, Analytical technologies in the biomedical and life sciences\| PubMed ID: 24786219	2014
Heterologous expression of moss light-harvesting complex stress-related 1 (LHCSR1), the chlorophyll a-xanthophyll pigment-protein complex catalyzing non-photochemical quenching, in Nicotiana... The Journal of biological chemistry\| PubMed ID: 26260788	2015
Enhanced GAD65 production in plants using the MagnICON transient expression system: Optimization of upstream production and downstream processing. Biotechnology journal\| PubMed ID: 26710327	2016
Design of a Type-1 Diabetes Vaccine Candidate Using Edible Plants Expressing a Major Autoantigen. Frontiers in plant science\| PubMed ID: 29765386	2018

Elisa Gecchele

Biography

JoVE Journal Publications

Other Publications